الدعم من قبل:

granite waste to replacement of river sand in concrete project

  • منزل
  • granite waste to replacement of river sand in concrete project
Images

Replacement of River Sand by M Sand Concrete – IJERT

Average increase in compressive strength of concrete was found to be 11%, 12%, 18.8% and 5% for partial replacement of natural sand by M-Sand with 10 %, 30 %, 50% and 70%. Th. ompressive strengt oncrete oncrete with Manufatured oncrete with Manufatured M20& M2g5rad Strength oncrete with river Tensile strengt Tensile strengt MIX PROPORTIONS

Utilization of Waste Marble Dust and Granite Dust for ... - JETIR

compressive strength when cement is also partially replaced with along with granite replacement. Only Granite replacement offers no such benefits. The compressive strength of concrete increases when natural river sand is replaced with 20% Marble dust powder. REFERENCES 1 Sakalkale, A. D., & Dhawale, G. D. (2014). Experimental study on use of ...

Geo Polymer Concrete with the Replacement of Granite Aggregate ... - IJSR

As the granite powder is replaced in place of sand it was found that at Na2SiO3 to NaOH ratio of 2.5. The results that were obtained were less than the basic mix. So by altering the Na2SiO3 to NaOH ratio to 2.25 the results were consistent compared to 2.5 and we obtained strength of 28.63 % increase in compressive strength,

Optimization of Granite Powder used as Partial Replacement to ... - IJERT

increment of 5% of Granite powder as partial replacement to cement. The adopted water to cement ratio was 0.53. Corrections for moisture absorption and moisture content were suitably applied for all the batches of mix. Manufactured Sand was used in place of the Natural River Sand. Research on Granite Powder as partial replacement

Characteristic Studies on Concrete by Partial Replacement of ... - IJERT

In present study the detailed characteristic studies of concrete is carried out by partial replacement of natural sand by waste granite powder in concrete composition with different percentages (0%, 10%, 20%, 30%, 40%, 50%).The mechanical properties of concrete like compressive strength, tensile strength are carried out by replacing the ...

EXPERIMENTAL INVESTIGATION ON CONCRETE WITH PARTIAL REPLACEMENT OF FINE ...

of waste granite powder is a main goal of this project. The granite fine concrete has better strength at 10% replacement. The Replacement of granite fine in concrete gives more Economical and provides better performance. REFERENCE: 1. N.Kiran Kumar, Dr.B.Damodhara Reddy, Smt.S.Aruna Jyoth "An Experimental Investigation on Strength Of Granite ...

COMPRESSIVE STRENGTH AND WORKABILITY OF LATERIZED QUARRY SAND CONCRETE

of quarry dust concrete, it was observed that concrete with partial replacement of river sand with quarry dust produced better compressive strength than conventional concrete up to 40% replacement level – a report in line with that of Sukesh et al [10]. Author therefore discouraged replacement of up to 50% with quarry dust.

What are the Materials for Replacement of Sand in Concrete?

The percentage passing 150 microns of manufactured sand is relaxed to 20% (while that of natural sand is limited to 10%). As per design and economics, crushed sand can be used to partially or fully replace river sand from a concrete mix. The Availability of crushed sand is not a concern as it can be manufactured from rocks in any season.

What are the Materials for Replacement of Sand in Concrete?

It can be replaced to the amount 25%. Its Availability is not a concern. 3. Washed Bottom Ash Bottom ashes are waste of coal fired thermal power plant generally disposed in landfills. Post washing (basically done to remove carbon, unwanted in concrete), it can be used for replacing sand to the amount of 35% in a concrete mix.

Effect of Granite Dust as Partial Replacement to Natural Sand on ...

The results of the study showed that for all concrete grades, 25% sand replacement level gave higher (7.9%) modulus of elasticity (MoE) while sand replacement level gave lower (8.6%) MoE ...

Granite Waste To Replacement Of River Sand In Concrete Project

And waste granite powder as partial replacement of fine aggregate in the concrete. varying grades of concrete by replacing of sand by granite powder and cement by glass powder. experimental investigation was natural river sand confirming to zone ii of is 383 1970. Get Price

Alternative fine aggregates in production of sustainable concrete- A ...

These alternatives are used either as whole or in different percentage replacement of river sand in concrete (Evangelista and De-Brito, 2014; Rajkumar 2014). ... The financial assistance for this project is provided by M/s ... produced from tunnel excavation rock (tuff manufactured sand, TS) and granite cutting waste (granite manufactured sand ...

Experimental Studies on Concrete Using the Partial Replacement of ...

This study is about the usage of finely grounded glass waste in concrete as replace-ment material to cement in of 5, 10, 15 and 20%, and manufactured sand had been ... cement and river sand in concrete making. To the reduction of waste materials on ... grade of cement is used throughout the project. Water is a decisive part of concrete

A review on Properties of Sustainable Concrete using granite dust as ...

Singh et al. (2016b) assessed the impact of replacement of fine aggregate by granite cutting waste on the hydration characteristics of the concrete. The experiments were carried out with the 0.3, 0.35 and 0.4 w/c ratios and for the percentage replacements of 0%, 10%, 25%, 40%, 55% and 70% XRD (X-ray diffractogram)

Strength and Durability Properties of Granite Powder Concrete

A substitute or replacement product for concrete industry needs to be found. The main parameter investigated in this study is M30 grade concrete with replacement of sand by granite powder by 0, 25 and 50% and cement was partial replacement with silica fume, fly ash, slag and super plasticizer.

(PDF) Replacement of river sand with sea sand and granite granules ...

Granite granules are the waste product obtained while cutting granite which is cost effective and sea sand is abundantly available in coastal areas when compared to river sand. This...

Use of Crushed Granite Fine as Replacement to River Sand in Concrete ...

The analysis also revealed that the replacement of sand with more than 30% crushed granite fine will result in the production of concrete that is uneconomical when compared with the use of crushed granite and river sand as coarse and fine aggregate respectively.

Alternative Sand: An Inevitable Resource to River Sand - NBM&CW

Over the past few years, researchers have studied natural crushed rock sand, copper slag, waste foundry sand, coal ash, recycled sand etc, which can also be used in concrete as fine aggregate. This paper gives an overview of alternative sand in construction and its positive impact on the environment.

Alternative Sand: An Inevitable Resource to River Sand - NBM&CW

Many researchers have found that 30% replacement of river sand (RS) with recycled fine aggregate (RFA) is more suitable [15, 16]. However, utilizing RFA produces low density concrete and RFA increases mechanical properties of the concrete with appropriate proportion of superplasticizer.

Use of Crushed Granite Fine as Replacement to River Sand in Concrete ...

The use of only Makurdi river sand as fine aggregate and gravel to produce grade C 35 concrete will cost N 16,559 a value lower than N 16,580 and N 16,622 obtained with the use of Makurdi river sand partially replaced with 10% and 30% crushed granite fine respectively.

Sandstone cutting waste as partial replacement of fine aggregates in ...

Sandstone cutting waste are sand-sized grains of mineral obtained from sedimentary rocks. This research aims to find the mechanical properties of concrete containing sandstone cutting waste collected from Bayana in Rajasthan state in India with the replacement of natural river sand. The study was carried out by opting three different w/c ratios ...

Effect of Granite Dust as Partial Replacement to Natural Sand on ...

Concrete Mix Proportioning. Following the provisions of IS-10262:2009 [], an M25 grade control concrete mix (CC01) was prepared using natural river sand as the fine aggregate.Keeping the amount of cement, fine and coarse aggregates, and water constant but partially replacing the sand quantity with granite dust, six additional mixes were prepared as given in Table 2.

STRENGTH AND DURABILITY ASPECTS OF PARTIAL REPLACEMENT OF SAND BY ...

Concrete was prepared with granite fines as a replacement of fine aggregate in 5 different percentages namely 0%, 5%, 10%, 15% and 20% and relevant tests have been carried out on strength such as compressive strength, Split tensile strength and Flexural strength. For each percent 4 specimens and a total of 20… Expand No Paper Link Available

REPLACEMENT OF NATURAL SAND IN CONCRETE BY WASTE PRODUCTS : A STATE OF ...

Published 2013. Engineering. In this paper an attempt is made to present a state-of the- art review of papers on replacement of natural sand by by-products and recyclable materials. This paper aims to deal with the current and future trends of research on the use of Manufactured Fine Aggregate (MFA) in Portland cement concrete.

Investigation of Concrete in Partial Replacement of Fine Aggregate ...

ingredient like aggregate also. So granite waste can be used as an alternative to this demand. However, our objective of the project is to study and compare the strength behavior of concrete using granite waste as a replacement material to fine aggregate. 2. METHODOLOGY The collect the journal about this project. Collection of material like ...

Comparative Study of Replacement of Natural Sand to Waste Tiles Sand in ...

For DC4 (60% replacement of natural sand to waste tile sand) increases the Shear Strength up to 38.07% after that it decreases. For Mix DC3 increases the Impact Strength up to 65.41% after that it decreases. Up to 40% replacement of natural sand to waste tile sand increases the Durability of concrete up to after that it decreases.

An Innovative Method of Replacing River Sand by Quarry Dust Waste in ...

This paper deals with replacement of sand used in concrete as fine agg. regates by the waste generated by the stone quarry industry. This study has made . an attempt to partially replace quarry dust in place of sand in M35 grade concrete. On experimentation, it was found that the. partial replacement of sand . with. 10% of quarry du. st. has ...